MULTIQUIP DA7000SS Spezifikationen PDF herunterladen (Seite 28)

PAGE 28 —DA7000 SERIES A.C. GENERATORS— OPERATION AND PARTS MANUAL — REV. #4 (08/07/09)

General Inspection

At least daily or prior to each use, the generator should be

cleaned and inspected for deficiencies. Check for loose,

missing or damaged nuts, bolts or other fasteners. Also check

for fuel or oil leaks.

Engine Side:

For a more detail engine maintenance schedule refer to the

KUBOTA Engine Shop and Operator's Manuals.

Air Cleaner

Every 50 hours: The air cleaner employed on the KUBOTA

Z482 series engines is a dry type, NEVER apply oil to it. If

generator is used in severe dusty areas service air cleaner

element more frequently.

1. Release the air cleaner retaining clamps (Figure 18) and

remove the air cleaner element.

2. Wipe the inside of the air cleaner with a clamp cloth and

remove all dust and debris that may have accumulated

inside air cleaner body.

3. Tap the edge of element lightly to allow heavy dust build-

up to fall off.

4. Use compressed air to clean air filter element. Blow

compressed air from the inside while turning the element.

5. Replace element once a year or every six cleanings.

DA7000 SERIES GENERATORS — MAINTENANCE (ENGINE)

When using compressed air to

clean air filter element, DO NOT

exceed 99 psi (686kPa).

Figure 18. Air Cleaner

NOTE

Oil Change

Every 100 hours: Change engine oil after the first 50 hours

of operation and 100 hours thereafter. Always check the

crankcase oil level prior to each use, or when the fuel tank

is filled. Insufficient oil may cause severe engine damage.

Make sure generator is level when checking oil level. The oil

level must be between the two notches on the dipstick as

shown in Figure 9.

Remove engine oil drain plug (Figure 19) and drain oil from

crankcase.For best results drain oil while engine is warm.

Reinstall oil drain plug, and add engine oil as specified in

Table 2. Crankcase oil capacity is .66 gal (2.5 liters).

When installing the oil filter, coat

rubber seal with a small amount

of lubricant (motor oil). DO NOT

over-tighten cartridge. Hand

tighten only.

NOTE

Oil Filter Cartridge

Every 200 hours: Replace the engine oil filter cartridge

(Figure 20) after every 200 hours of operation.

Figure 20. Oil Filter Cartridge

Figure 19. Engine Oil Drain Plug

1 2 ... 23 24 25 26 27 28 29 30 31 32 33 ... 165 166

Kommentare zu diesen Handbüchern

Keine Kommentare

MULTIQUIP DA7000SS Spezifikationen Seite 28

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Stromgeneratoren MULTIQUIP DA7000SS